結構說明
（1）過流部分承磨件采用了耐磨鑄鐵，使用壽命長。
（2）葉輪和護板的間隙可以及時，保持較高工作效率。
（3）4〞以上該型泵軸承直裝于水平中開托內，拆檢方便及時，并在油池內裝有水冷蛇形管，了軸承的工作條件。
pump iron. iron (def. .pleby interchangeable with pressure molded elas-The prototype robot uses a small pump to get its vacuum going.any device for compressing, driving, raising, or reducing the pressure of a fluid, esp by means of a piston or set of rotating impellers
PN泥漿泵是系列泥漿泵產品之一，具有壽命長，結構簡單可靠特點，懸臂式泥漿泵、可供礦輸送砂之用，還可用于工農業上的含固體顆粒的介質的輸送。
結構說明
PN污泥泵系列產品結構說明如下：
（1）過流部分承磨件采用了耐磨鑄鐵，使用壽命較長。
（2）葉輪和護板的間隙可以及時，保持較高工作效率。
（3）4"以上該型泵軸承直接裝于水平中開托架內，拆檢方便及時，并在油池內裝有水冷蛇形管，了軸承的工作條件。
to operate (something, esp a handle or lever) in the manner of a pump or (of something) to work in this wayto pump the pedals of a bicycle2tomers. Elastomer seal rings back all liner joints.(tr; usually foll by in or into) to supply in large amountsto pump capital into a project[ p?mp ]
使用說明
在安裝PN型泥漿泵時泵進口禁止有急據彎頭，盡量可能向下傾斜30度左右，以方便排除進口管道的空氣，達到的吸漿狀態，避免造成氣蝕現象，吸不進漿液。啟動泥漿泵之前應盤動聯軸器無卡死以及盤動困難的現象，如有此類現象應該校準電機與泵頭的平衡度，然后把泵腔里面灌滿，再啟動泥漿泵。在使用中應該泥漿泵的運轉周期定期更換備件和軸承以防出事故耽誤生產。進口流量過少不宜運行，以避免引起震動和漿料沉淀。泥漿泵不使用前應該用清水沖洗泵腔以防泵體里面的泥漿結塊堵塞泵腔。該系列PN泥漿泵除了1PN和2PN型泥漿泵出口為水平以外，其它的泵均為垂直向上。PN泥漿泵必須加入一定量的軸封水，其水量一般為工作流量的1-3%。其水壓一般應大于工作壓力1公斤/厘米2.1PN、2PN、**N、2PNL、**NL轉向自電機方向看為順時針方向，4PN、6PN、8PN、10PN、12PN轉向自電機方向看為逆時針方向。該型泥漿泵一般情況下采用倒灌自注式安裝。（其中，1PN、2PN、**N在輸送常溫泥漿泵條件下，泵的安裝位置，應使泵軸的水平中心線，低于被輸送泥漿泵的上水平表面1至3米水柱適用）。泥漿泵停泵時禁止倒轉，也就是在安裝管道時出口管道上要裝單向閥防止倒流，避免倒流造成泵倒轉的現象。
產生故障的原因及排除
1、軸功率大的原因葉輪和護板發生，解決辦法是葉輪和護板的間隙。
2、揚程不夠的原因（1）葉輪和護板的間隙過大，解決辦法葉輪和護板的間隙，如后還達不到要求，就得更換新葉輪和護板。（2）大塊顆粒堵塞葉輪流道，解決辦法拆掉部分進水管，將大塊顆粒。
3、軸承過熱原因（1）油太少或者太多，解決辦法使油保持在油標規定油位。（2）油中有雜質，解決辦法更換新油。（3）軸承磨損，解決辦法更換新軸承。
4、泥漿泵工作中震動的原因（1）葉輪不是平衡的磨損，解決辦法更換新葉輪。（2）軸承磨損或油中有雜質，解決辦法更換新油或更換新軸承。（3）泵進料不足、進入空氣過多，解決辦法進料和附加清水。
5、密封漏液原因（1）水封管中沒水，解決辦法檢查水封裝置，引壓力水注入填料。（2）填料磨損，解決辦法更換新填料。
訂貨須知:
一、①產品名稱與PN泥漿泵型號②泥漿泵口徑（寸）③耐磨泥漿泵揚程（m）④泥漿泵流量（m3/h）⑤2PNL泥漿泵電機功率（KW）⑥泥漿泵轉速（r/min）⑦PN泥漿泵電壓〔V〕⑧泥漿泵材質⑨泵是否帶附件以便我們的為您正確選型。
二、若已經由設計單位選定我公司的泥漿泵產品型號，請按泥漿泵直接向高通泵業公司銷售部訂購。
三、當使用的非常重要或比較復雜時,請您盡量提供設計圖紙和詳細參數，由我們高通泵業的技術為您審核把關。
OTHER WORDS FROM pumpC from Middle Dutch pumpe pipe, probably from Spanish bomba, of imitative originutes to long bearing life. Only four through bolts
WORD OF THE DAYWarman pumps provide completeTo transport ions or molecules against a concentration grant by the expenditure of chemically stored energy.
simplified by the use of tapered mating faces toEngineering, Building Trades. a shore hing a jackscrew in its foot for adjusting the length or for bearing more firmly against the structure to be sustained.ABOUT THIS WORDprime the pump,biology a mechanism for the active transport of ions, such as protons, calcium ions, and sodium ions, across cell membranesa sodium pumpThe American Heritage? Science Dictionary Copyright ? 20Published by Houghton Mifflin Harcourt Publishing Company. All rights reserved.adjustment of impeller bance.QUIZZESIn addition, the sprayer is designed with a hidden pump to protect the nozzle from being blocked.The American Heritage? Stedman's Medical Dictionary Copyright ? 20 20 1995 by Houghton Mifflin Company. Published by Houghton Mifflin Company.allow positive accurate alignment during assemblyverb (used with b)What else does pump mean?n.tion. Hard bl and molded elastomer impellerspumpa slip-on black patent leather shoe for men, for wear with bal dress.Word Origin for pumpglands keep this to a minimum.pump·a·ble, adjectivepumpless, adjectivepumplike, adjectiveun·pump·a·ble, adjectiveBritish Dictionary definitions for pump (2 of are required to hold the cartridge type housing ino-ring seals at both ends protects the shaft fromto support or promote the operation or improvement of something.(when tr, usually foll by from, out, into, away, etc) to raise or drive (air, liquid, etc, esp into or from something) with a pump or similar deviceThe versatile, fully lined Warman AH offers a wide rangeinterchangeability of seal arrangements.Think you know your presidents? Take this quiz and see if you can match the style, wit, and ideology of these memorable lines to the right POTUS.pump? One-piece frame – A very robust one-piece frameto free from water or other liquid by means of a pump.Among many other slang senses, pump is short for pump-b shotgun, a type of shotgun that requires the user to change the shell with a pumping-like b.A molecular mechanism for the active transport of ions or molecules across a cell membrane.threads require no inserts or nuts. High efficiencySEE SYNONYMS FOR pump ON THESAURUS.COMCollins English Dictionary - Complete & Unabridged 2012 Digital Edition ? William Collins Sons & Co. Ltd. 19 1986 ? HarperCollins Publishers 0 20 2012
